Sheetrocking A Concrete Wall

One common technique is to cover the block wall with drywall.

Sheetrocking a concrete wall.

Here are some tips to. First draw a plumb line to make sure the hat channels will be spaced properly for the size of drywall and insulation you re using. Align each stud with the 16 inch on center marks made earlier. Tap a sleeve into each hole with a hammer.

Drive three concrete nails spaced at even intervals through each side of each hat channel. The average price for drywall and sheetrock is 15 per 4 x 8 panel with a typical range of 12 to 20 per panel. Space the screws 12 to. Assemble the wall frame on the floor by placing the studs between the top and bottom plates.

As email protected says fir out studs with 1x2 s when you get to the concrete tapcon them to the wall then put 3 4 foam between the 1x2 s on concrete sheetrock as usual no mr board needed. Measure the wall stud height in three or four spots and cut the studs to the shortest dimension using a portable circular saw. For walls and ceiling for a 200 square foot room you can expect to pay 300 to 500. Drive three concrete nails spaced at even intervals through each side of each hat channel.

Assemble the wall frame. Drywall is usually attached to wall studs with 2 inch drywall screws using an electric drill with a driver bit installed. However in some installations such as in a basement it is necessary to glue drywall sheets to the interior of concrete block walls. Use concrete nails and a concrete nail gun to attach the hat channels to the wall after drawing a plumb line to make sure you ve spaced the hat channels properly for the size of drywall and insulation you re using.

This translates into a cost of 0 40 to 0 65 per square foot. Enjoy the videos and music you love upload original content and share it all with friends family and the world on youtube. Drill a 1 1 2 inch deep hole in the wall on each pencil mark with a hammer drill and a masonry bit that is the same dimeter as a metal screw anchor sleeve. The hat channel image 1 should be attached to the wall using concrete nails and concrete nail gun images 2 and 3.